Microsurfacing (2010)

Below is the uncorrected machine-read text of this chapter, intended to provide our own search engines and external engines with highly rich, chapter-representative searchable text of each book. Because it is UNCORRECTED material, please consider the following text as a useful but insufficient proxy for the authoritative book pages.

68 American Society of Testing and Materials, Practices for Design, Testing, and Construction of Slurry Seal, D3910- 98R04, Volume 04.03, West Conshohocken, Pa., 2007a. American Society of Testing and Materials, Practice for Design, Testing, and Construction of Micro-Surfacing, D6372-05, Volume 04.03, West Conshohocken, Pa., 2007b. Anderson, K.W., J. Uhlmeyer, and L. Pierce, “PCCP Texture Modification Using the Skidabrader,” Report No. WA-RD 667.1, Washington State Department of Transportation, Olympia, 2007, 14 pp. Asphalt Emulsion Manufacturers Association, Asphalt Emul- sion Surface Treatment Descriptions, Asphalt Emulsion Manufacturers Association, Annapolis, Md., n.d., p. 13 [Online]. Available: http://www.pavementpreservation. org/toolbox/resources.html [accessed Aug. 3 2010]. Asphalt Institute, Asphalt Overlays for Highway and Street Rehabilitation, Publication MS-17, Asphalt Institute, Lex- ington, Ky., June 1983, 115 pp. Asphalt Institute, Asphalt Surface Treatments—Construction Techniques, Educational Series No. 12 (ES-12), Lexington, Ky., 1988, 28 pp. Asphalt Institute, Asphalt Surface Treatments—Specifications, Educational Series No. 11 (ES-11), Lexington, Ky., n.d., 8 pp. Austroads, Sprayed Sealing Guide, Austroads, Sydney, Aus- tralia, 2003a, 18 pp. Austroads, Guidelines and Specification for Bituminous Slurry Surfacing, Austroads Publication No. AP–T26/03, Sydney, Australia, 2003b, 51 pp. Bae, A. and S.M. Stoffels, “Economic Effects of Microsur- facing on Thermally-Cracked Pavements,” KSCE Journal of Civil Engineering, Vol. 12, No. 3, 2008, pp. 177–185. Bausano, J.P., K. Chatti, and R.C. Williams, “Determining Life Expectancy of Preventive Maintenance Fixes for Asphalt-Surfaced Pavements,” Transportation Research Record: Journal of the Transportation Research Board, No. 1866, Transportation Research Board of the National Academies, Washington, D.C., 2004, pp. 1–8. Bennett, R., “Blastrac Shot Blasting Trial and Technical Assessment,” Geotest Civil Services, Bendigo Victoria, Australia, June 2007, 23 pp. Berg, K., K. Burns, and B. Sharp, “Type III Micro Surfacing to Extend the Life of Concrete Pavement on I-70 in Region Four,” Research Report UT-09.03, Utah Department of Transportation, Salt Lake City, 2009, 30 pp. Bergkamp Inc., Slurry Seal and Microsurfacing Equipment, Pavement Preservation Solutions, Bergkamp Inc., Salina, Kans., 2010, p. 11. Bickford, A., “The Difference Between Slurry Seal and Microsurfacing,” AEMA Newsletter #2, Asphalt Emulsion Manufacturers Association, Annapolis, Md., 2008, p. 3. California Department of Transportation, Maintenance Tech- nical Advisory Guide Volume 1: Flexible Pavement Preser- vation, 2nd ed., (MTAG-FP), Chapter 9: “Microsurfac- ing,” 2009, Caltrans, Sacramento [Online]. Available: http://www.dot.ca.gov/hq/maint/FPMTAG_Chapter9_ Microsurfacing_June2009.pdf [accessed June 17, 2010]. California Department of Transportation, Maintenance Tech- nical Advisory Guide Volume 2: Rigid Pavements, 2nd ed., (MTAG-RP), 2008, Caltrans, Sacramento [Online]. Avail- able: http://www.dot.ca.gov/hq/maint/MTAGChapter9- Microsurfacing.pdf [accessed Apr. 30, 2010]. Chehovits, J. and L. Galehouse, “Energy Usage and Green- house Gas Emissions of Pavement Preservation Processes for Asphalt Concrete Pavements,” Proceedings of the 1st International Conference on Pavement Preservation, New- port Beach, Calif., Apr. 2010, pp. 27–42. Committee on Management of Quality Assurance, Transporta- tion Research Circular E-C074: Glossary of Highway Quality Assurance Terms, Transportation Research Board of the National Academies, Washington, D.C., May 2005, 40 pp. Davis, L., “County of San Diego Finds Successful Chip Seal Methods,” Asphalt Contractor, May 1999, pp. 1–4. de Fortier Smit, A., Synthesis of NCAT Low-Noise HMA Stud- ies, NCAT Report 08-01, National Center for Asphalt Technology, Auburn, Ala., Mar. 2008, p. 1. Erwin, T. and S.L. Tighe, “Safety Effect of Preventive Maintenance: A Case Study of Microsurfacing,” Trans- portation Research Record: Journal of the Transportation Research Board, No. 2044, Transportation Research Board of the National Academies, Washington, D.C., 2008, pp. 79–86. Federal Highway Administration, Contract Administration Core Curriculum Participant’s Manual and Reference Guide, U.S. Department of Transportation, Washington, D.C., 2006 [Online]. Available: http://www.fhwa.dot.gov/ programadmin/contracts/core03.cfm [accessed Mar. 13, 2010]. Federal Highway Administration, Pavement Preservation Treatment Construction Guide, “Chapter 8—Microsur- facing,” Washington, D.C., 2007 [Online]. Available: http://fhwapap34.fhwa.dot.gov/NHI-PPTCG/chapter_8/ unit3.htm [accessed Apr. 12, 2010]. Federal Highway Administration, Field Guide for Polymer Modified Asphalt Emulsions, Mar. 2009, 27 pp. [Online]. Available: http://www.cflhd.gov/programs/techDevelop- ment/pavement/polymer/documents/01_Field_Guide_for _Polymer_Modified_Emulsions.pdf [accessed Apr. 12, 2010] Federal Highway Administration, “Pavement Preservation Expert Task Group Strategic Plan,” U.S. Department of Transportation, Washington, D.C., Jan. 27, 2010a, pp. 1–5. REFERENCES

69 Federal Highway Administration, Pavement Friction Man- agement, Technical Advisory T 5040.38, June 17, 2010b [Online]. Available: http://www.fhwa.dot.gov/pavement/ t504038.cfm [accessed Aug. 8, 2010]. Federal Lands Highway Division, Standard Specifications for Construction of Roads and Bridges on Federal Highway Projects, FP-03, Federal Highway Administration, U.S. Department of Transportation, Washington, D.C., 2003, pp. 277–280. Feldman, W. and P. Feldman, “Waiting on You,” Concrete Progress, Vol. 1, No. 3, Nov. 2007, p. 13. Fugro-BRE/Fugro South, LP, “Phase I Report: Slurry Seal/ Micro-Surface Mix Design Procedure,” California Depart- ment of Transportation, Sacramento, Mar. 2004, 144 pp. Galehouse, L., J.S. Moulthrop, and R.G. Hicks, “Principles for Pavement Preservation: Definitions, Benefits, Issues and Barriers,” TR News, Sep./Oct. 2003, pp. 4–9. Gao, R., “Evaluation of Incentive/Disincentive Contracting Methods for Highway Construction Projects,” MS Thesis, Purdue University, Lafayette, Ind., 2010, p. 124. Geiger, D.R., “Pavement Preservation Definitions,” Federal Highway Administration Memorandum, Washington, D.C., Sep. 12, 2005, p. 2. Georgia Department of Transportation, Standard Specifica- tions, Section 428—Microsurfacing, Atlanta, 2001, 7 pp. Gillies, J., “Saskatchewan Professionals Lead the Way on Climate Change,” The Professional Edge, APEGS, No. 100, Winter 2006, pp. 6–9. Gransberg, D.D., “Life Cycle Cost Analysis of Surface Retexturing with Shotblasting as a Pavement Preservation Tool,” Transportation Research Record, Journal of the Transportation Research Board, No. 2108, Transportation Research Board of the National Academies, Dec. 2009, pp. 46–52. Gransberg, D.D. and D.M.B. James, NCHRP Synthesis 342: Chip Seal Best Practices, Transportation Research Board of the National Academies, Washington, D.C., 2005, 124 pp. Gransberg, D.D. and C. Reimer, “Impact of Inaccurate Engi- neer’s Estimated Quantities on Unit Price Contracts,” Jour- nal of Construction Engineering and Management, ASCE, Vol. 135, No. 11, Nov. 2009, pp. 1138–1145. Gransberg, D.D., K.R. Molenaar, and J.N. Datin, NCHRP Synthesis 376: Quality Assurance in Design-Build Projects, Transportation Research Board of the National Academies, Washington, D.C., 2008, p. 39. Gransberg, D.D., E. Scheepbouwer, and S.L. Tighe, “Per- formance-Specified Maintenance Contracting: The New Zealand Approach to Pavement Preservation,” Proceed- ings, 1st International Conference on Pavement Preserva- tion, Transportation Research Board, Newport Beach, Calif., Apr. 2010, pp. 103–116. Hall, J.W., “Guide for Pavement Friction,” American Asso- ciation of State Highway and Transportation Officials, Washington, D.C., 2006 [Online]. Available: http://www. transportation.org/sites/design/docs/Friction%20Guide %20with%20AASHTO%20changes%20-%208-14-2007 %20line%20nos.pdf [accessed Sep. 22, 2007]. Helali, K., T.J. Kazmierowski, A. Bradbury, and M.A. Karan, “Application of Network-Level Pavement Management System Technology to a Unique Pavement Deterioration Problem,” Transportation Research Record 1524, Trans- portation Research Board, National Research Council, Washington, D.C., 1996, pp. 67–76. Hicks, G.R., K. Dunn, and J.S. Moulthrop, “Framework for Selecting Effective Preventive Maintenance Treatments for Flexible Pavements,” Transportation Research Record 1597, Transportation Research Board, National Research Council, Washington, D.C., 1997, pp. 1–10. Hicks, R.G., J.S. Moulthrop, and J. Daleiden “Selecting a Pre- ventive Maintenance Treatment for Flexible Pavements,” Transportation Research Record 1680, Transportation Research Board, National Research Council, Washington, D.C., 1999, pp. 1–12. Hicks, G.R., S.B. Seeds, and D.G. Peshkin, “Selecting a Preventive Maintenance Treatment for Flexible Pavements,” Foundation for Pavement Preservation, Washington, D.C., June 14, 2000, 87 pp. Hixon, C.D. and D.A. Ooten, “Nine Years of Microsurfac- ing in Oklahoma,” Proceedings, Transportation Research Board, National Research Council, Washington, D.C., 1993, 26 pp. Holleran, G., “ABC’s of Slurry Surfacing,” Asphalt Contractor Magazine, July 2001. Hunt, E., Asphalt Pavement Maintenance and Rehabilitation Selection Guide, Master’s Thesis, Department of Civil Engineering, Oregon State University, Corvallis, June 1991. International Slurry Surfacing Association (ISSA), Quick Set Emulsified Asphalt, ISSA TB 102, ISSA, Annapolis, Md., 2007, 13 pp. International Slurry Surfacing Association (ISSA), Inspec- tor’s Manual for Slurry Systems, ISSA, Annapolis, Md., 2010a, 106 pp. International Slurry Surfacing Association (ISSA), Recom- mended Performance Guideline for Micro Surfacing, ISSA A143 (revised Feb. 2010), ISSA, Annapolis, Md., 2010b, 16 pp. Jahren, C.T., K.L. Bergeson, A. Al-Hammadi, S. Celik, and G. Lau, Thin Maintenance Surfaces: Phase One Report, Center for Transportation Research and Education, Iowa State University, Ames, Apr. 1999. Jahren, C.T. and K.R. Behling, “Thin Maintenance Surface Treatments Comparative Study,” Transportation Research Record: Journal of the Transportation Research Board, No. 1866, Transportation Research Board of the National Academies, Washington, D.C., 2004, pp. 20–27. Johnson, N., T.J. Wood, and R.C. Olson, “Flexible Slurry– Microsurfacing System for Overlay Preparation,” Trans- portation Research Record: Journal of the Transportation Research Board, No. 1989, Transportation Research Board of the National Academies, Washington, D.C., 2007, pp. 18–26. Kohn, L.T., “Methods in Case Study Analysis,” The Center for Studying Health System Change, Technical Publica- tion No. 2, Washington, D.C., June 1997, pp. 2–4.

Labi, S., G. Lamptey, and S. Kong, “Effectiveness of Micro- surfacing Treatments,” Journal of Transportation Engineer- ing, ASCE, Vol. 133, No. 5, May 1, 2007, pp. 298–308. Laungrungrong, B., B. Mobasher, and D. Montgomery, Development of Rational Pay Factors Based on Concrete Compressive Strength Data, Research Report FHWA-AZ- 08-608, Arizona Department of Transportation, Phoenix, 2007, 98 pp. Li, Y., A. Cheetham, S. Zaghloul, K. Helali, and W. Bekheet, “Enhancement of Arizona Pavement Management Sys- tem for Construction and Maintenance Activities,” Trans- portation Research Record: Journal of the Transporta- tion Research Board, No. 1974, Transportation Research Board of the National Academies, Washington, D.C., 2006, pp. 26–36. Louisiana Department of Transportation and Development (LaDOTD), “State Project Nos. 022-05-0053, 022-60-0049, and 074-04-0012 Special Provisions,” LaDOTD, Baton Rouge, 2006, p. D-17. Lyon, C. and B. Persaud, “Safety Effects of Targeted Program to Improve Skid Resistance,” Transportation Research Record: Journal of the Transportation Research Board, No. 2068, Transportation Research Board of the National Academies, Washington, D.C., 2008, pp. 135–140. Main Roads, Specification 507 Microsurfacing, Main Roads, Perth, Western Australia, 2008, 20 pp. Manion, M. and S.L. Tighe, “Performance-Specified Main- tenance Contracts: Adding Value Through Improved Safety Performance,” Transportation Research Record: Journal of the Transportation Research Board 1990, Transportation Research Board of the National Academies, Washington, D.C., 2007, pp. 72–79. Marquis, B., The Use of Micro-Surfacing for Pavement Preser- vation, Technical Report 02-3, Construction Report Trans- portation Research Division, Maine Department of Trans- portation, Bangor, Apr. 2002, 17 pp. Marquis, B., The Use of Micro-Surfacing for Pavement Preser- vation, Technical Report 02-3, Interim Report—First Year; Transportation Research Division, Maine Department of Transportation, Bangor, Apr. 2004, 23 pp. Marquis, B., The Use of Micro-Surfacing for Pavement Preser- vation, Technical Report 02-3, Final Report Transportation Research Division, Maine Department of Transportation, Bangor, Apr. 2009, 26 pp. McHattie, R.L. and J.A. Elieff, Cost-Effective Rut Repair Methods, Alaska DOT Research Report FHWA-AK-RD- 01-04, Fairbanks, 2001, 63 pp. Minnesota Department of Transportation, Standard Specifi- cations for Construction, Minnesota Department of Trans- portation, St. Paul, 2005, p. 776. Miquel, S. and J. Condron, “Assessment of Road Maintenance by Contract,” Infrastructure and Urban Development Department Report INU 9I, The World Bank, Washington D.C., 1991, p. 3. Missouri Department of Transportation, Specification Book for Highway Construction, Missouri Department of Trans- portation, Columbia, 2004, p. 413.10.2.1. 70 Moulthrop, J.S., “Slurry/Micro-Surface Mix Design Proce- dure,” Northeast Pavement Preservation Partnership, War- wick, R.I., Dec. 11, 2007 [Online]. Available: http://www. tsp2.org/files_tsp2/resource/Slurry%20Seal%20System %20Pooled%20Fund%20Study%20Update.pdf [accessed Apr. 12, 2010]. Moulthrop, J., T. Thomas, and B. Ballou, “Initial Improve- ment in Ride Quality of Jointed, Plain Concrete Pave- ment with Microsurfacing: Case Study,” Transportation Research Record 1545, Transportation Research Board, National Research Council, Washington, D.C., 1996, pp. 3–11. Moulthrop, J., T. Thomas, B. Ballou, and H. King, “Choose the Right Tool for the Distress,” Asphalt Contractor, Vol. 6, No. 9, Sep. 1999, pp. 8–12. National Highway Institute, Pavement Preservation Treat- ment Construction Guide, Chapter 8—“Microsurfacing,” Federal Highway Administration, Washington, D.C., 2007 [Online] Available: http://fhwapap34.fhwa.dot.gov/NHI- PPTCG/chapter_8/unit3.htm [accessed Apr. 12, 2010]. Nebraska Department of Roads, Pavement Maintenance Man- ual, Nebraska Department of Roads, Lincoln, 2002, 72 pp. New Mexico Department of Transportation (NMDOT), Stan- dard Specifications for Highway and Bridge Construction, NMDOT, Santa Fe, 2007, p. 487. New Mexico Department of Transportation (NMDOT), NMDOT Pavement Preservation Manual, NMDOT, Santa Fe, 2009, p. 173. New York State DOT (NYSDOT), Pavement Rehabilitation Manual—Volume III: Preventive Maintenance Treatments and Selection, NYDOT Materials Bureau, Albany, June 1999. North Atlantic Division, “Guidance: IDIQ MATOC for Air Force Installations East of the Mississippi,” Fact Sheet for Corps Distribution, U.S. Army Corps of Engineers, Boston, Mass., 2006, pp. 2–3. Noyce, D.A., H.U. Bahia, J.M. Yambó, and G. Kim, “Incor- porating Road Safety into Pavement Management: Maxi- mizing Asphalt Pavement Surface Friction for Road Safety Improvements—Literature Review & State Surveys,” Mid- west Regional University Transportation Center, Traffic Operations and Safety Laboratory, Madison, Wis., Apr. 29, 2005, 110 pp. Ohio Department of Transportation (ODOT), 2006 Status of the Warranty Program, Research Report, ODOT, Colum- bus, 2007, 32 pp. Ohio Department of Transportation (ODOT), “Supplemental Specification 881, Microsurfacing with Warranty,” ODOT, Columbus, Apr. 18, 2008, p. 1–6. Olsen, S., “An Introduction to Slurry Seal and Microsurfac- ing Systems,” Maintenance Technical Advisory Guide, Volume I, Flexible Pavement Preservation, 2nd ed., Cali- fornia Department of Transportation, Sacramento, Mar. 7, 2008 [Online]. Available: http://www.techtransfer.berkeley. edu/pavementpres08downloads/PP08Olsen.pdf [Apr. 12, 2010]. Pennsylvania Department of Transportation (PennDOT), “Special Provision 9483-3004, Cold-Laid Latex Modified

71 Emulsion Pavement Course, Type A, SRL-E,” PennDOT, District 3, Valley, June 15, 2009, pp. 2–4. Pittenger, D.M., “Life Cycle Cost-Based Pavement Preserva- tion Treatment Design,” M.S. Thesis, University of Okla- homa, Norman, 2010, 124 pp. Price, G.R., “Microsurfacing Warranties,” unpublished Pow- erPoint presentation, Intermountain Slurry Seal, Salt Lake City, Utah, 2010, 26 pp. Province of Ontario, “Construction Specification for Micro- surfacing,” Ontario Provincial Standard, OPSS 336, Toronto, ON, Canada, Nov. 2009, 22 pp. Riemer, C., D.D. Gransberg, M. Zaman, and D. Pittenger, “Comparative Field Testing of Asphalt and Concrete Pave- ment Preservation Treatments in Oklahoma,” Proceedings, 1st International Conference on Pavement Preservation, Transportation Research Board, Newport Beach, Calif., Apr. 2010, pp. 447–460. Road Science, LLC, “Ralumac® Micro-surfacing,” WWW document [Online]. Available: http://www.roadscience llc.com/brands/maintenance/ralumac [accessed June 19, 2010]. Schexnayder, C.J. and R. Mayo, Construction Management Fundamentals, McGraw–Hill Professional, New York, N.Y., 2004, pp. 282–283. Senadheera, S., D.D. Gransberg, and T. Kologlu, Seal Coat Field Manual, Research Report TX-1787-P, Texas Depart- ment of Transportation, Austin, Feb. 2001, p. 244. Shober, S.F. and D.A. Friedrichs, “A Pavement Preserva- tion Strategy,” Proceedings of the 77th Annual Meeting of Transportation Research Board, National Academies, Washington, D.C., 1997. Small Business Administration, “Business Plan for the Small Construction Firm,” Small Business Administration Pub- lication MP-5, Department of Commerce, Washington, D.C., 2009. Smith, R.E. and C.K. Beatty, “Microsurfacing Usage Guide- lines,” Transportation Research Record: Journal of the Transportation Research Board, No. 1680, Transportation Research Board of the National Academies, Washington, D.C., 1999, pp. 13–18. Takamura, K., K.P. Lok, and R. Wittlingerb, “Microsurfac- ing for Preventive Maintenance: Eco-Efficient Strategy,” International Slurry Seal Association Annual Meeting, Maui, Hawaii, 2001, p. 5. Temple, W., S. Shah, H. Paul, and C. Abadie, “Performance of Louisiana’s Chip Seal and Microsurfacing Program,” Transportation Research Record: Journal of the Trans- portation Research Board, No. 1795, Transportation Research Board of the National Academies, Washington, D.C., 2002, pp. 3–16. Thompson, B.P., S.D. Anderson, J.S. Russell, and A.S. Hanna, “Guidelines for Warranty Contracting for Highway Con- struction,” Journal of Management in Engineering, ASCE, Vol. 18, No. 3, 2002, pp. 129–138. Uhlman, B., “Eco-Efficiency of Microsurfacing,” Proceed- ings, AEMA-ARRA-ISSA Annual Meeting, Sunny Isles, Fla., Mar. 2010, 56 pp. Virginia Department of Transportation (VDOT), Material Certification Schools, Class Schedule Brochure, VDOT, Richmond, 2010, p. 2. Washington State Department of Transportation (WSDOT), Asphalt Seal Coats, Technology Transfer, WSDOT, Olympia, 2003. Washington State Department of Transportation (WSDOT), Wear Resistant Pavement Study, Experimental Final Report No. WA-RD 657.2, WSDOT, Olympia, June 2009, 122 pp. Watson, D. and D. Jared, “Georgia Department of Trans- portation’s Experience with Microsurfacing,” Trans- portation Research Record: Journal of the Transporta- tion Research Board, No. 1616, Transportation Research Board of the National Academies, Washington, D.C., 1998, pp. 42–47. Watson, S., “SBR Latex Modification,” Presentation, 2005 Rocky Mountain Asphalt Conference, Denver Colo., 2005, p. 13. West, K., R. Smith, and D.C. Vanskike, Micro-surfacing Guidelines for Use and Quality Assurance, Texas Trans- portation Institute Research Report 0-1289, College Sta- tion, Aug. 1996, 49 pp. Wood, T.J., “Minnesota Experiences with Innovative Micro- surfacing,” Proceedings, Midwest Pavement Preservation Partnership, Missoula, Montana, October 2007, 19 pp. [Online], Available: http://www.tsp2.org/library/document/ minnesota-experiences-with-innovative-micro-surfacing. Wood, T.J. and G. Geib, 1999 Statewide Micro Surfacing Project, Research Report MN/RC-2001-11, Minnesota Department of Transportation, St. Paul, 2001, 60 pp. Wood, T.J., “Minnesota Experiences with Innovative Micro- surfacing,” Proceedings, Midwest Pavement Preservation Partnership, Missoula, Montana, October 2007, 19 pp. [Online], Available: http://www.tsp2.org/library/document/ minnesota-experiences-with-innovative-micro-surfacing. Yager, T.J., “Pavement Surface Properties,” Report A2B07: Committee of Surface Properties—Vehicle Interaction, Millenium On-Line Publication, Transportation Research Board, National Research Council, Washington, D.C., 2000, [Online], Available: http://onlinepubs.trb.org/online pubs/millennium/00087.pdf [accessed Sep. 26, 2007]. Zaniewski, J. and M. Mamlouk, “Pavement Preventive Maintenance Key to Quality Highways,” Transportation Research Record: Journal of the Transportation Research Board, No. 1680, Transportation Research Board of the National Academies, Washington, D.C., 1999, pp. 26–31.